竹之宝-环保型竹材漂白剂
一、产品介绍:
竹之宝-环保型竹材漂白剂是维德林化针对竹材制品新开发的一款环保型竹材漂白产品,其具有适应竹材种类范围广、含量高、漂白速々度快、阻燃、去油脱脂、干燥速度快、安全无毒无刺激性气味、漂白后的竹制产品不易返黄、不易霉变、不易开裂等一系列特点. 改变了以往传统型竹材漂白剂渗透深度浅、打磨砂光易露底、漂白后干燥速度慢、上漆后易发红返黄等缺点.
二、主要成分:氧化助剂,还原助剂,防霉助剂,耐黄变助剂,氧化酶助剂,阳离子助渗剂,氧化促进剂、水性防裂剂,表面活性剂等不含重金属、甲醛等有毒有害物质。
三、产品参数:
1、外观:无色透明」液体.
2、气味:无气味.
3、比重; 1.12.
4、PH值:A B剂混合后为9.5
5、水溶性:易溶于水.
6、有效活性物含量:65% .
7、执行标准:国家标准GB18582-2001.
四、适用范围:
竹之宝-环保型竹材漂白剂可有效的处理竹材地板、竹材线条、竹材门窗、竹木家具、竹木≡工艺品、竹材↑编织工艺品、竹皮制品、竹丝制品,百叶窗等竹材制品出现的变色、色斑、水积等深色现象,使用方便、安全、无浪费、防裂、去油脂、耐黄变、抗霉变,阻燃等一系列优点.
五、使用方法:
使用时将竹之宝-环保型竹材漂白剂产品的A剂、B剂按1:1比例混合好(搅拌均匀)操作上可采用刷涂、浸泡、喷洒、滚涂等方法.
1、采用刷涂法时,可直接将A B剂1:1混合好后的溶液刷涂在竹材表面,如竹材同一表面上出现双色色差时,可先把同一表面上出现的深色部位进行先期刷涂1—2次,待竹材上的深色部位水份稍干20-40后颜色变淡后,再把整个竹材板面进行整体涂刷后即可达到竹材板面整体颜色色泽均匀一致的漂白效果。竹之宝-环保型竹材漂白剂每公斤可刷涂15-20平方米此工艺主要适用于卐竹地板,竹材家具板,竹材墙壁板等平面造型的施工操作.
2、采用浸泡法时,首先将需要浸泡的竹材产品表面的灰尘,竹屑清理干净(以免影响漂白药液的渗透性)然后将需要漂白的竹材产品直接放在1:1混合好后的A B剂溶液里进行浸泡处理,也可根据白度的要求兑水浸泡,浸泡的时间越长白度越高。一般浸泡5-60分钟左右,A B剂1:1混合好后的↙溶液可在24-36小时内反复循环使用,超过36小时如需继续使用,可适当再加入A B混合好后的新药剂30-40%进行重新激活处理,以确保药剂持续有效。此工艺主要适用于竹材工艺品,竹皮,竹材家具配件等小件竹材制品的施工操作.
3、采用喷洒法时,可直接将A B剂1:1混合好后的溶液装在手持塑料喷壶或不锈钢喷枪里(注意喷壶或喷枪切记不能密封,因A B 剂1:1混合好后会产生一定量的气体)进行喷洒,竹之宝-环保型竹材漂白剂每公斤可喷洒12-18平方米-此工艺主要适用于大件或异型竹材质品,竹材家具,细目工板四周等不规格竹材制品的施工操作.
4、采用滚涂法时,可直接将A B剂1:1混合好后的溶液倒在存水槽里,调整好涂布机滚轮的间距,以确保滚轮能『够有效的接触到药水,如需要处理的竹材表面上出现双色色差时,可先把深色部位进行提前30分钟手工刷涂1—2次,待竹材上的深色部位颜色逐渐变淡后,再把整个竹材板面进行整体辊涂处理,每公斤可涂布面积为15—18平方米。此工艺主要适用于竹地板,竹材家具板,竹材墙壁板,竹材贴面板等平面竹材制品的大批量施工操作.
六、注意事项:
1、操作︽者应佩戴耐酸碱橡胶手套,禁止用手直接接触,如不慎接触到皮肤或溅入眼睛时应及时用自来水进行冲洗,溅入眼睛严重时应及时送医治疗.
2、采用喷洒法时应该注意操作车间的通风,操作者应站在上风口.
3、操作时禁止吸烟,并远离小孩.操作现场,严禁烟火.
4、配制溶液时用请选用塑料容器或不锈钢容器,禁止用铁、铜,铝等金属容器配制.
5、竹之宝-环保型竹材漂白剂应现配现用,严禁任意更改配比比例,以免造成不必要的浪费.
6、竹之宝-环保型竹材漂白剂A B剂为配套产品,严禁将该漂白剂与其他漂白产品配合使用,以免发生意外和危险.
7、竹之宝-环保型竹材漂白剂应储存在避光、阴凉、通风处,未及时用完或者暂且不用时请存放于室内.避免长期进行太阳暴晒. 存放时,应注意A B剂分开存放,并作好明确标示.
8、有效使用期限:常温条件下三年内有效
Bamboo, bamboo, green bamboo bleach
First, product introduction:
The treasure of bamboo - environmentally friendly bamboo bleaching agent is Vader forest for the development of new bamboo products is a environmental protection type bamboo bleaching products having to bamboo wide range, high content, bleaching speed, flame retardant, degreasing, drying speed is fast, safe, non-toxic no stimulation of gas smell, bleaching of bamboo products not easily yellowing, not easy to moldy, not easy to crack a series of characteristics. Changed the traditional type bamboo bleaching agent penetration depth is shallow, sanding light easily, bleaching after drying speed is slow, painted red back yellow and other shortcomings.
Two main components: Assistant oxidant, reducing agent, anti mildew agent, anti yellowing agent, oxidase promoter and cationic auxiliary infiltration agent, oxidizing agent, water of anti cracking agent, surface active agent, does not contain heavy metals, formaldehyde and other toxic and harmful substances.
Three, product parameters:
1, appearance: colorless transparent liquid.
2, smell: no smell.
3, proportion; 1.12.
4, pH value: B A after mixing for 9.5
5, water solubility: soluble in water.
6, effective active content: 65%.
7, the implementation of standards: national standard GB18582-2001.
Four, the scope of application:
Weave bamboo bamboo treasure - environmentally friendly bleaching agent can effectively processing bamboo floor, bamboo line, bamboo floor, bamboo furniture, bamboo crafts, bamboo crafts, bamboo leather products, bamboo silk products, blinds and other bamboo products discoloration, stains, water and dark phenomenon, convenient use, safety, no waste, crack, to oil, yellowing resistance, anti mildew, flame retardant, etc. a series of advantages.
Five, the use of methods:
When the bamboo is used, the A agent and B agent of the environmentally friendly bamboo bleaching agent product can be mixed with 1:1 ratio (stir evenly), and the method can be applied to brush coating, soaking, spraying and rolling.
1, using brush coating method, directly after a B agent 1:1 mixed solution brush painted on bamboo surface, such as bamboo with a surface appear double color color, first appearing on the same surface dark parts of early brush 1 - 2 times, until the bamboo on the dark parts of the water slightly dry after 20 40 color fades, then the overall brushing the whole surface of the bamboo board can achieve the bamboo surface color overall color uniform bleaching effect. Bamboo Bao - environmentally friendly bamboo bleaching agent per kilogram can be painted 15-20 square meters this process is mainly applicable to the construction of bamboo flooring, bamboo furniture panels, bamboo wall panels and other graphic design.
2, by soaking method. First of all, it will require soaking bamboo products surface dust, bamboo shavings clean (so as not to affect the permeability of the bleaching liquid) will then need to bleaching of bamboo products placed directly in a 1:1 mixture of a B solution soaking, can also according to the whiteness of the demands against water immersion, immersion time is Changbai degree higher. General immersion 5-60 minutes. After a B agent 1:1 mixed solution can be within 24-36 hours repeatedly recycled more than 36 hours to continue to use, appropriate to add a B mixed drug agent 30-40% to re activating treatment to ensure sustained and effective medicament. This process is mainly suitable for bamboo crafts, bamboo skin, bamboo furniture accessories and other small construction operation of bamboo products.
3, using the method of spraying, directly after a B agent 1:1 mixed solution in handheld plastic watering can or stainless steel spray gun (note the watering can or spray gun remember not sealed, due to a B agent 1:1 mixture will produce a certain amount of gas) were sprayed, bamboo treasure of environment-friendly type bamboo drift white agent per kilogram can be sprayed 12-18 square meters - this process is mainly used in large and special shaped bamboo quality, bamboo furniture, breakdown of the plate around the specifications of bamboo products construction operation.
4, the roll coating process, can be directly after a B agent 1:1 mixed solution of inverted in the storage tank, to adjust the spacing between the coating roller, to ensure that the roller can effectively access to medicine, such as the need to process the bamboo on the surface appear double color, the dark parts of 30 minutes earlier manual brush 1 - 2 times, until the bamboo on the dark parts of the color gradually fades, then the whole bamboo board to overall and coating treatment, per kilogram can be coated with an area of 15 - 18 square metres. This process is mainly applicable to bamboo flooring, bamboo furniture board, bamboo wall board, bamboo plywood and other flat bamboo products of large quantities of construction operation.
Six, matters needing attention:
1, the operator should wear acid and alkali resistant rubber gloves, to prohibit direct contact with the hand, such as accidentally exposed to the skin or splashing into the eyes should be promptly washed with tap water, splashing into the eye should be timely treatment of medical treatment.
2, should pay attention to the operation of the ventilation, the operator should stand on the air outlet.
3, the operation of smoking, and away from the child. Operating site, no fireworks.
4, when the solution is formulated with the use of plastic containers or stainless steel containers, prohibit the use of iron, copper, aluminum and other metal containers.
5, bamboo treasure - green bamboo bleaching agent should be used, is strictly prohibited to change the proportion of the ratio, so as not to cause unnecessary waste.
6, bamboo - green bamboo bleaching agent B A agent as a complete product, it is strictly prohibited to use the bleach and other bleaching products, in order to avoid accidents and dangerous.
7, bamboo treasure of environment-friendly type bamboo bleaching agent should be stored in dark, cool, ventilated place, not timely finished temporarily or when not in use, please store indoors. Avoid long-term exposure to the sun. When stored should be pay attention to a B agent stored separately, and clearly marked.
8, the effective use of the term: under normal conditions for three years under normal conditions
竹の宝-環境保護型竹漂白剤
一、製品紹介:
竹の宝-環境保護型竹漂白剤は林化竹制品に対してヴィドラー新開発の1項の環境保護型竹製品を持つ漂白、竹の種類に適応範囲が広く、含有量が高く、漂白速度は速い、難燃性、去油脱脂、乾燥速度が速く、安全無毒無刺激性ガスの味、漂白後の竹製品易返黄、カビが生えにくい、割れにくいなど一連の特徴.変わった以前伝統型竹漂白剤浸透深淺、磨き砂光易秘密を漏らす、漂白後乾燥速度が遅く、漆の後易赤み返黄などの欠点。
二、主要成分:酸化剤、還元剤、カビ剤、耐黄変助剤、酸化酵素剤、カチオン助浸透剤、酸化剤、水的防裂剤、表面活性剤などの重金属を含む、ホルムアルデヒドなどの有害物質。
三、製品パラメーター:
1、外観:無色透明液体。
2、匂い:無臭。
さん、比重;1。
4、pH:A B剤混合後は788として
ご、水溶性:は水に溶けやすい。
6、有効活性物含有量:65 %
ななしち、実行の標準:国家標準GB18582-2001。
4、適用範囲:
竹の宝-環境保護型竹漂白剤の有効処理竹床、竹線、竹の扉と窓は、竹木家具、竹木工芸品、竹編み工芸品、竹の皮製品、竹繊維製品、ブラインドなど竹制品の出現の変色やシミ、水積もりなどダーク現象、使うのは便利で、安全、無浪費、防裂、油脂、耐黄変、抗カビが生え、難燃など一連の利点。
五、使用法:
使用時には竹の宝-環境保護型竹漂白剤製品のA剤、B剤にいち:いち割合まぜ(攪拌して平均的に操作を採用して、液体に浸して、ブラッシングだの、滾塗るなど方法。
いち、にブラッシング法を採用して、直接AをB剤いち:いち混合後の溶液ブラシに塗って竹の表面には、竹のように同じ表面に出て二色色収差のとき、先に同じ表面に現れたダーク部位をあらかじめブラッシングいち—に回、あとで濃い竹ちょっとした後の色―部位に水分を薄くなった後に、更に全体を竹パネルをブラッシング後全体で到着竹板面全体の色の色均一一緻の漂白効果。竹の宝-環境保護型竹漂白剤1キロはブラッシング15~20平方メートルのこの工芸主に適用于竹床、竹家具板、竹壁板など平面の造形の施工操作。
に、採用に法を必要とする時、まず浸す竹製品の表面のほこり、竹くず片付け(に影響を与えないよう漂白薬液の浸透性)を漂白の竹製品が直接置いていち:いち混合後のAはB溶液に浸し処理剤を、白度の要求に応じて兌水に浸し、浸す時間が長白度が高い。一般的に5-60分ごろ、AはB剤いち:いち混合後の溶液は24-36時間以内に繰り返し循環使用を36時間が必要な場合、使用を続けると、適当に加えA B混合後の新薬剤30-40%の再活性化処理を確保するために、有効な薬剤が続く。このプロセスの主な竹工芸品に適用し、竹の皮、竹家具部品などの小物の竹製品の施工操作。
さん、散布法を採用した時、直接AをB剤いち:いち混合後の溶液を手にプラスチックじょうろやステンレスガンに注意じょうろやガンネットワークアーない密封して、A B剤いち:いち混ざったらが一定量の気体)を散布し、竹の宝-環境保護型竹漂白剤散布一キログラムごとには12-18平方メートル-この工芸主要適用粗大や異形質品竹竹、家具、ディテール工板週りなどない竹製品規格の施工操作。
よんしよ、採用たぎって塗り時、直接AをB剤いち:いち混合後の溶液が倒れて存水槽に、調整コーターホイールの間隔を確保するため、ホイールが有効に触れ薬液、が必要な処理の竹の表面に現れ二色色収差時、まずダーク部位を早めに行さんじゅう分手ブラッシングいち—に回、あとで濃い色の竹の部位が薄くなった後に、更に全体をパネルを塗る竹全体ロール処理、1キロが塗布面積はじゅうご—じゅうはち平方メートル。このプロセスの主な適用于竹床、竹家具板、壁に貼って竹板、竹パネルなど平面竹◆制品の大量施工操作。
六、注意事項:
1、操作者は耐アルカリ性手袋、手で直接接触し、接触して皮膚に接触して目に接触する時直ちに水道水で洗い流し、目が深刻な時、直ちに医治療治療を送るべきだ。
2、吹きかけ法を採用する時は操作の作業場の換気を注意するべきで、オペレーターは羽口に立つべきです.
3、操作時に喫煙禁止、子供を離れ、作業現場、火気厳禁。
4、調合溶液時にプラスチック容器又はステンレス容器、鉄、銅、アルミなど金属容器を使用することを禁止します。
ご、竹の宝-環境保護型竹漂白剤は現現配で、任意の配分割合変更は厳禁、不必要な廃棄物を避けるべき。
ろく、竹の宝-環境保護型竹漂白剤A B剤を厳禁する製品、当該漂白剤と他の漂白製品を合わせて使用が起こらないように、意外と危険。
ななしち、竹の宝-環境保護型竹漂白剤は貯水存在光を避けるため、涼しいの、風に、直ちに使い切ってあるいはしばらく未使わない時は室内に保存して下さい。避け長期を太陽にさらさ.保管時、注意すべきことは、AはB剤を明確に別れて保管して、表示できる。
8、有効使用期限:常温条件下3年以内⌒有効